Danforth Donnalley Laundry Products Company On April 17, 2013, James Danforth, president of Danforth Donnalley (D D) Laundry Products Company, called to order a meeting of the financial directors The purpose of the meeting was to make a capital budgeting decision with respect to the introduction and production of a new product, a liquid detergent called Blast D D was formed in 1985 with the merger of Danforth Chemical Company, headquartered in Seattle, Washington, producers of Lift Off detergent, the leading detergent on the West Coast and Donnalley Home Products Company, headquartered in Detroit, Michigan, makers of Wave detergent, a major Midwestern laundry product As a result of the merger, D D was producing and marketing two major product lines Although these products were in direct competition, they were not without product differentiation Lift Off was a low suds, concentrated powder, while Wave was a more traditional powder detergent In the face of increased competition and technological innovation, D D had spent large amounts of time and money over the past four years researching and developing a new, highly concentrated liquid laundry detergent D Ds new detergent, which they called Blast, had many obvious advantages over the conventional powdered products It was felt that with Blast the consumer would benefit in three major areas Blast was so highly concentrated that only 2 ounces was needed to do an average load of laundry as compared with 8 to 12 ounces of powdered detergent Moreover, because it was a liquid, it was possible to pour Blast directly on stains and hard to wash spots, eliminating the need for a presoak and giving Blast cleaning abilities that powders could not possibly match And finally, Blast would be packaged in a lightweight, unbreakable plastic bottle with a sure grip handle, making it much easier to use and more convenient to store than the bulky boxes of powdered detergents with which it would compete The meeting was attended by James Danforth, president of D D Jim Donnalley, director of the board Guy Rainey, vice president in charge of new products Urban McDonald, controller and Steve Gasper, a newcomer to D Ds financial staff, who was invited by McDonald to sit in on the meeting Danforth called the meeting to order, gave a brief statement of its purpose, and immediately gave the floor to Guy Rainey Rainey opened with a presentation of the cost and cash flow analysis for the new product, and passed out copies of the projected cash flows (see Exhibits 1 and 2) In support of this information, he provided some insight into how these calculations were determined Rainey proposed that the initial cost for Blast included $500,000 for the test marketing, which was conducted in the Detroit area and completed in the previous June, and $2 million for new specialized machinery and packaging equipment The estimated life for the machinery and equipment was 15 years, after which they would have no salvage value This 15 year estimated life assumption coincides with company policy set by Donnelley not to consider cash flows occurring more than 15 years into the future, as estimates that far ahead tend to become little more than blind guesses Rainey cautioned against taking the annual cash flows shown in Exhibit 1 at face value since portions of these cash flows actually are a result of sales that had been diverted from Lift Off and Wave For this reason, Rainey also produced the annual cash flows shown in Exhibit 2, which had been adjusted to include only those cash flows incremental to the company as a whole 1 EXHIBIT 1 D D Laundry Products Company Total Annual Cash Flows from the Acceptance of Blast (including those flows resulting from sales diverted from the existing product lines) Year Cash Flows 1 $280,000 2 280,000 3 280,000 4 280,000 5 280,000 6 350,000 7 350,000 8 350,000 9 350,000 10 350,000 11 250,000 12 250,000 13 250,000 14 250,000 15 250,000 At this point, discussion opened between Donnalley and McDonald, and it was concluded that the opportunity cost of funds (cost of capital) is 10 Gasper then questioned the fact that no costs were included in the proposed cash budget for plant facilities (buildings and structures), which would be needed to produce the new product Rainey replied that, presently, Lift Offs production facilities were being utilized at only 55 of capacity, and since these facilities were suitable for use in the production of Blast, no new plant facilities other than the specialized machinery and packaging equipment mentioned above need to be acquired for the new product line It was estimated that full production of Blast would only require 10 of the plant capacity McDonald asked if there had been any consideration of increased working capital needed to operate the investment project Rainey answered that there had and that this project would require $200,000 of additional working capital at the start of the project Further, at the end of projects estimated life, this money would be transferred to other projects and thus will never leave the firm and will always be in liquid form therefore it was not considered an inflow in fifteen years and, hence, the recovery of working capital at the end of projects estimated life was not included in the calculations Donnalley argued that this project should be charged something for its use of the current excess plant facilities His reasoning was that if an outside firm tried to rent this space from D D, it would be charged somewhere in the neighborhood of $100,000 annually, and since this project would compete with other current projects, it should be treated as an outside project and charged as such However he went on to acknowledge that D D has a strict policy forbidding the renting or leasing out of any of its production facilities If they didnt charge for facilities, he concluded, the firm might end up accepting projects that under normal circumstances would be rejected From here, the discussion continued, centering on the questions of what to do about the lost contribution from other projects, the test marketing costs, the working capital, and opportunity cost of renting existing excess plant facilities 2 EXHIBIT 2 D D Laundry Products Company Incremental Annual Cash Flows from the Acceptance of Blast (not including those flows resulting from sales diverted from the existing product lines) Year Cash Flows 1 $250,000 2 250,000 3 250,000 4 250,000 5 250,000 6 315,000 7 315,000 8 315,000 9 315,000 10 315,000 11 225,000 12 225,000 13 225,000 14 225,000 15 225,000 What are the NPV, payback, IRR, MIRR, PI, and accounting rate of return (ARR) of this project, including cash flows resulting from lost sales from existing product lines What does each technique measure and what assumptions does it make What are the NPV, payback, IRR, MIRR, PI, and ARR of this project excluding these flows (For ARR calculations above, you can assume that specialized machinery and packaging equipment is depreciated straight line over 15 years down to zero book value ) Under the assumption that there is a good chance that competition will introduce a similar product if D D doesnt, would you accept or reject this project

The Answer is in the image, click to view ...

Answered step by step

Verified Expert Solution

Link Copied!

Question

1 Approved Answer

Posted on Jul 28, 2024

Danforth & Donnalley Laundry Products Company On April 17, 2013, James Danforth, president of Danforth & Donnalley (D&D) Laundry Products Company, called to order a

Danforth & Donnalley Laundry Products Company

On April 17, 2013, James Danforth, president of Danforth & Donnalley (D&D) Laundry Products Company, called to order a meeting of the financial directors. The purpose of the meeting was to make a capital budgeting decision with respect to the introduction and production of a new product, a liquid detergent called Blast.

D&D was formed in 1985 with the merger of Danforth Chemical Company, headquartered in Seattle, Washington, producers of Lift-Off detergent, the leading detergent on the West Coast; and Donnalley Home Products Company, headquartered in Detroit, Michigan, makers of Wave detergent, a major Midwestern laundry product. As a result of the merger, D&D was producing and marketing two major product lines. Although these products were in direct competition, they were not without product differentiation: Lift-Off was a low-suds, concentrated powder, while Wave was a more traditional powder detergent.

In the face of increased competition and technological innovation, D&D had spent large amounts of time and money over the past four years researching and developing a new, highly concentrated liquid laundry detergent. D&Ds new detergent, which they called Blast, had many obvious advantages over the conventional powdered products. It was felt that with Blast the consumer would benefit in three major areas. Blast was so highly concentrated that only 2 ounces was needed to do an average load of laundry as compared with 8 to 12 ounces of powdered detergent. Moreover, because it was a liquid, it was possible to pour Blast directly on stains and hard-to-wash spots, eliminating the need for a presoak and giving Blast cleaning abilities that powders could not possibly match. And finally, Blast would be packaged in a lightweight, unbreakable plastic bottle with a sure-grip handle, making it much easier to use and more convenient to store than the bulky boxes of powdered detergents with which it would compete.

The meeting was attended by James Danforth, president of D&D; Jim Donnalley, director of the board; Guy Rainey, vice president in charge of new products; Urban McDonald, controller; and Steve Gasper, a newcomer to D&Ds financial staff, who was invited by McDonald to sit in on the meeting. Danforth called the meeting to order, gave a brief statement of its purpose, and immediately gave the floor to Guy Rainey.

Rainey opened with a presentation of the cost and cash flow analysis for the new product, and passed out copies of the projected cash flows (see Exhibits 1 and 2). In support of this information, he provided some insight into how these calculations were determined. Rainey proposed that the initial cost for Blast included $500,000 for the test marketing, which was conducted in the Detroit area and completed in the previous June, and $2 million for new specialized machinery and packaging equipment. The estimated life for the machinery and equipment was 15 years, after which they would have no salvage value. This 15-year estimated life assumption coincides with company policy set by Donnelley not to consider cash flows occurring more than 15 years into the future, as estimates that far ahead tend to become little more than blind guesses.

Rainey cautioned against taking the annual cash flows shown in Exhibit 1 at face value since portions of these cash flows actually are a result of sales that had been diverted from Lift-Off and Wave. For this reason, Rainey also produced the annual cash flows shown in Exhibit 2, which had been adjusted to include only those cash flows incremental to the company as a whole.

EXHIBIT 1 D&D Laundry Products Company Total Annual Cash Flows from the Acceptance of Blast (including those flows resulting from sales diverted from the existing product lines)

Year Cash Flows

1 $280,000

2 280,000

3 280,000

4 280,000

5 280,000

6 350,000

7 350,000

8 350,000

9 350,000

10 350,000

11 250,000

12 250,000

13 250,000

14 250,000

15 250,000

At this point, discussion opened between Donnalley and McDonald, and it was concluded that the opportunity cost of funds (cost of capital) is 10%. Gasper then questioned the fact that no costs were included in the proposed cash budget for plant facilities (buildings and structures), which would be needed to produce the new product.

Rainey replied that, presently, Lift-Offs production facilities were being utilized at only 55% of capacity, and since these facilities were suitable for use in the production of Blast, no new plant facilities other than the specialized machinery and packaging equipment mentioned above need to be acquired for the new product line. It was estimated that full production of Blast would only require 10% of the plant capacity.

McDonald asked if there had been any consideration of increased working capital needed to operate the investment project. Rainey answered that there had and that this project would require $200,000 of additional working capital at the start of the project. Further, at the end of projects estimated life, this money would be transferred to other projects and thus will never leave the firm and will always be in liquid form; therefore it was not considered an inflow in fifteen years and, hence, the recovery of working capital at the end of projects estimated life was not included in the calculations.

Donnalley argued that this project should be charged something for its use of the current excess plant facilities. His reasoning was that if an outside firm tried to rent this space from D&D, it would be charged somewhere in the neighborhood of $100,000 annually, and since this project would compete with other current projects, it should be treated as an outside project and charged as such. However he went on to acknowledge that D&D has a strict policy forbidding the renting or leasing out of any of its production facilities. If they didnt charge for facilities, he concluded, the firm might end up accepting projects that under normal circumstances would be rejected.

From here, the discussion continued, centering on the questions of what to do about the lost contribution from other projects, the test marketing costs, the working capital, and opportunity cost of renting existing excess plant facilities.

EXHIBIT 2 D&D Laundry Products Company Incremental Annual Cash Flows from the Acceptance of Blast (not including those flows resulting from sales diverted from the existing product lines)

Year Cash Flows

1 $250,000

2 250,000

3 250,000

4 250,000

5 250,000

6 315,000

7 315,000

8 315,000

9 315,000

10 315,000

11 225,000

12 225,000

13 225,000

14 225,000

15 225,000

What are the NPV, payback, IRR, MIRR, PI, and accounting rate of return (ARR) of this project, including cash flows resulting from lost sales from existing product lines? What does each technique measure and what assumptions does it make? What are the NPV, payback, IRR, MIRR, PI, and ARR of this project excluding these flows? (For ARR calculations above, you can assume that specialized machinery and packaging equipment is depreciated straight-line over 15 years down to zero book value.) Under the assumption that there is a good chance that competition will introduce a similar product if D&D doesnt, would you accept or reject this project?