Problem 10-12 Variance Analysis in a Hospital [LO10-1, LO10-2, LO10-3] John Fleming, chief administrator for Valley View Hospital, is concerned about the costs for tests in the hospital's lab. Charges for lab tests are consistently higher at Valley View than at other hospitals and have resulted in many complaints. Also, because of strict regulations on amounts reimbursed for lab tests, payments received from insurance companies and governmental units have not been high enough to cover lab costs. Mr. Fleming has asked you to evaluate costs in the hospital's lab for the past month. The following information is available: a. Two types of tests are performed in the lab-blood tests and smears. During the past month, 500 blood tests and 2,500 smears were performed in the lab. b. Small glass plates are used in both types of tests. During the past month, the hospital purchased 12,500 plates at a cost of $45,000. 1,500 of these plates were unused at the end of the month; no plates were on hand at the beginning of the month C. During the past month, 1,500 hours of labor time were recorded in the lab at a cost of $15,825 d. The lab's variable overhead cost last month totaled $10,650 Dung thepaestnonthw1 soo hours of bontme were recorded in the lalo ta cot month Valley View Hospital has never used standard costs. By searching industry literature, however, you have determined the following nationwide averages for hospital labs Plates: Three plates are required per lab test. These plates cost $3.75 each and are disposed of after the test is completed Labor: Each blood test should require 0.6 hours to complete, and each smear should require 0.30 hours to complete. The average cost of this lab time is $11.50 per hour Overhead Overhead cost is based on direct labor-hours. The average rate for variable overhead is $6.60 per hour